0 Members and 1 Guest are viewing this topic.

*

Offline WVGuy11

CF Moto Z6-EX Bogs Down
« on: April 18, 2016, 12:07:42 PM »
I have a 2013 CF Moto Z6-EX with just over 1,700 miles.  It runs fine when the temperature gauge registers two or under.  Once it warms up and hits 3, the engine bogs downs, and you have to play with the gas pedal to keep it running.  Sometimes it will die, but starts right back up.  When the temperature drops back down to two, it will start running good again until it happens all over again.  The machine has plenty of antifreeze, a full tank of gas, installed a new air filer before I went out for a ride, the fan is working properly, and there are no trouble codes flashing.   Anyone know what might be causing the problem?

Here's a link to a video so you can hear what's happening:

https://onedrive.live.com/redir?resid=263022C128AD9CA6!12841&authkey=!AEG-8E4JFD3Mvic&ithint=video%2cMOV
« Last Edit: April 23, 2016, 08:36:13 AM by WVGuy11 »

*

Offline NMKawierider

Re: CF Moto Z6-EX Bogs Down
« Reply #1 on: April 18, 2016, 12:26:54 PM »
That's interesting. It acts like at some point either the fuel supply is hampered or the ignition voltage falls below what it takes to charge the coils. And interestingly the third bar on mine is where the fan comes on. You say the fan is running fine. So..maybe that draw is dropping the power to the ECU or fuel pump because of a bad connection somewhere...and these things are known for that-especially in the fuse block. I would start there.  There was also a report of something like this that was caused by a bad glass main fuse that is located at or behind the battery.
« Last Edit: April 18, 2016, 12:28:35 PM by NMKawierider »
2015 Z Force 800 53/Trail EPS
Custom Air Intakes | Custom Exhaust Mod | SuperATV Harness | Custom Fenders | Custom Skid/Rock Sliders | 27" GBC Grim Reapers | Seizmik Mirrors |Конструктор Doors | Dr Pulley Sliders | 1.5" Wheel Spacers | BENZ Silencer (as needed) | SATV Flip Windshield W\ Rear Shield | Dual Light Bars | Diamond Plate Storage |7- 9.7" GPS Systems | Bandit Springs Rear & Gen-3 Shocks Front | Cage Chop Mod

My Videos On YouTube

*

Offline WVGuy11

Re: CF Moto Z6-EX Bogs Down
« Reply #2 on: April 18, 2016, 01:03:14 PM »
Thanks for the quick reply! I was thinking something related to the fuel. I'll check my connections and the fuse and see what I can find when I get home.

*

Offline chuddly

Re: CF Moto Z6-EX Bogs Down
« Reply #3 on: April 21, 2016, 03:40:11 PM »
follow your fuel lines also and make sure that they are not to close to any heat source.  I have seen it on other machines where you will actually boil the fuel in the line and cause issues like this.
I can imagine a world completely at peace.  A world where there are no weapons, no war, and no violence at all.  And I can imagine us taking over that world because they would never expect it.

Re: CF Moto Z6-EX Bogs Down
« Reply #4 on: April 22, 2016, 08:40:30 AM »
My buddies machine did this on a ride last year to hatfield mccoy I dont know what it was but it just snapped out of it we were on the way back to park it and it just started running right?
2012 Z6 trail
Homemade roof/Stereo system/KFI Snowplow/3 inch lift/28 inch maxxis bighorn 2.0/led running lights/thats it no more mods until i get the 800ex/wrong custom skid plate

*

Offline Cosmosdan

Re: CF Moto Z6-EX Bogs Down
« Reply #5 on: April 22, 2016, 08:08:14 PM »
I have had the hot fuel thing before on another machine. Not sure where this would happen on the Z6, but worth a look to make sure.
2013 Z6 Trail
Iron Baltic skid plates
UE Boom Speaker mount
RZR 800 Shocks
Mostly stock trail riding
25g. Rollers and A1

2016 Outlander max 570
Too new for mods yet

*

Offline tauton

Re: CF Moto Z6-EX Bogs Down
« Reply #6 on: April 22, 2016, 08:33:28 PM »
I got told the fuel pumps die and can't keep the pressure up. so it bogs down

*

Offline NMKawierider

Re: CF Moto Z6-EX Bogs Down
« Reply #7 on: April 22, 2016, 08:38:28 PM »
Crap in tanks..even water will stop-up the intake sock.
2015 Z Force 800 53/Trail EPS
Custom Air Intakes | Custom Exhaust Mod | SuperATV Harness | Custom Fenders | Custom Skid/Rock Sliders | 27" GBC Grim Reapers | Seizmik Mirrors |Конструктор Doors | Dr Pulley Sliders | 1.5" Wheel Spacers | BENZ Silencer (as needed) | SATV Flip Windshield W\ Rear Shield | Dual Light Bars | Diamond Plate Storage |7- 9.7" GPS Systems | Bandit Springs Rear & Gen-3 Shocks Front | Cage Chop Mod

My Videos On YouTube

*

Offline Cosmosdan

Re: CF Moto Z6-EX Bogs Down
« Reply #8 on: April 22, 2016, 10:49:40 PM »
If it is the pump than put a pressure gage on it and find out. Looks easy to get to and replace if that is your issue.
2013 Z6 Trail
Iron Baltic skid plates
UE Boom Speaker mount
RZR 800 Shocks
Mostly stock trail riding
25g. Rollers and A1

2016 Outlander max 570
Too new for mods yet

*

Offline WVGuy11

Re: CF Moto Z6-EX Bogs Down
« Reply #9 on: April 23, 2016, 07:39:07 AM »
I was thinking the fuel pump too.  I called the dealer and they said the fuel pressure should be around 43 psi. Upon checking mine it is only reading 28 psi. So I'm heading to the dealer today to get a fuel pump and see if that fixes it.

*

Offline WVGuy11

Re: CF Moto Z6-EX Bogs Down
« Reply #10 on: April 23, 2016, 12:29:45 PM »
Picked up the new fuel pump, installed it, and checked the psi. It read 43 like the dealer said it should. Took it back in the mountain here in WV and it did fine. The temperature gauge went to 3, the fan kicked on and the machine didn't bog down. I'm fairly sure the problem is fixed! I'll know more once I take it out on a longer ride when it's warmer and not raining.

*

Offline NMKawierider

Re: CF Moto Z6-EX Bogs Down
« Reply #11 on: April 23, 2016, 12:55:11 PM »
Good. Makes sense.
2015 Z Force 800 53/Trail EPS
Custom Air Intakes | Custom Exhaust Mod | SuperATV Harness | Custom Fenders | Custom Skid/Rock Sliders | 27" GBC Grim Reapers | Seizmik Mirrors |Конструктор Doors | Dr Pulley Sliders | 1.5" Wheel Spacers | BENZ Silencer (as needed) | SATV Flip Windshield W\ Rear Shield | Dual Light Bars | Diamond Plate Storage |7- 9.7" GPS Systems | Bandit Springs Rear & Gen-3 Shocks Front | Cage Chop Mod

My Videos On YouTube

*

Offline tim needs help

Re: CF Moto Z6-EX Bogs Down
« Reply #12 on: May 18, 2016, 05:55:53 AM »
hi, how do I go about checking the fuel pump pressure, iv got the same sort of problems but worse, I had the fuel pump changed a while back because it failed completely, at times mines wont even tick over when warmed up.

*

Offline NMKawierider

Re: CF Moto Z6-EX Bogs Down
« Reply #13 on: May 18, 2016, 07:15:38 AM »
hi, how do I go about checking the fuel pump pressure, iv got the same sort of problems but worse, I had the fuel pump changed a while back because it failed completely, at times mines wont even tick over when warmed up.
I suppose it's like any of them. Pull the supply line off, attach a fuel pressure gauge and turn the key on.
2015 Z Force 800 53/Trail EPS
Custom Air Intakes | Custom Exhaust Mod | SuperATV Harness | Custom Fenders | Custom Skid/Rock Sliders | 27" GBC Grim Reapers | Seizmik Mirrors |Конструктор Doors | Dr Pulley Sliders | 1.5" Wheel Spacers | BENZ Silencer (as needed) | SATV Flip Windshield W\ Rear Shield | Dual Light Bars | Diamond Plate Storage |7- 9.7" GPS Systems | Bandit Springs Rear & Gen-3 Shocks Front | Cage Chop Mod

My Videos On YouTube

*

Offline Cosmosdan

Re: CF Moto Z6-EX Bogs Down
« Reply #14 on: May 19, 2016, 12:56:06 AM »
I haven't checked the service manual, is it not in there?
2013 Z6 Trail
Iron Baltic skid plates
UE Boom Speaker mount
RZR 800 Shocks
Mostly stock trail riding
25g. Rollers and A1

2016 Outlander max 570
Too new for mods yet